Our Products

Rotary Evaporator

Laboratory equipment

Jacketed Reactor

Contact Us

We Cherish All Interactions

Evaporators - an overview | ScienceDirect Topics

Evaporators - an overview | ScienceDirect Topics

The climbing film evaporator does not work well at very high vacuum (low vapor density, less drag). c. The climbing film concept does not work well with very viscous liquids. This is probably the most important limitation to the widespread use of climbing film tubular evaporators .

How to use a Rotary Evaporator

How to use a Rotary Evaporator

A typical rotary evaporator has a water bath that can be heated in either a metal container or crystallization dish. This keeps the solvent from freezing during the evaporation process. The solvent is removed under vacuum, is trapped by a condenser and is collected for easy reuse or disposal.

Evaporators | Dairy Processing Handbook

Evaporators | Dairy Processing Handbook

Concentration of a liquid by evaporation under vacuum was introduced in 1913. The process was based on a British patent by E.C. Howard, which covered a steam-heated, double-bottomed vacuum pan with condenser and vacuum pump. Concentration. Zoom. Fig. 6.5.1. General principle of evaporation. A partition is heated by hot steam and vapour .

Schutte & Koerting - Barometric Condensers

Schutte & Koerting - Barometric Condensers

Steam Jet Vacuum Systems Barometric Condensers Principle of Operation. Fig. 590 and Fig. 591 Multi-Jet Barometric Condensers are generally employed where low cost water is available in ample quantity. It is the simplest design of all barometric condensers, and requires no auxiliary air pump or pre-cooler.

Evaporators Plant, Ejectors, Vacuum Pumps, Heat Exchangers .

Evaporators Plant, Ejectors, Vacuum Pumps, Heat Exchangers .

- Spreading of liquid to each tube and forming the thin film across an area of the tube is the principle of falling film evaporator. - It can be used for processing, which is sensitive, have a high rate of specific heat transfer, for low fouling, low viscous fluid & for non crystalline solutions.

D-Velpac® Evaporator | LCI Corporation

D-Velpac® Evaporator | LCI Corporation

Under these very favorable heat and mass transfer conditions, rapid evaporation occurs, and the vapor exits near the top for condensation in the surface condenser. The distillate flows out of the condenser into a batch receiver. The concentrate exits through the bottom cone of the evaporator .

Heat Exchangers | Chem Process Systems

Heat Exchangers | Chem Process Systems

15 Natraj Industrial Estate, Sanand-Viramgam Highway, Vasna-lyava, Sanand - 382 170. A'bad. India. Phone : +91 9904133336 / 37 /38

Rotary Evaporators | Fisher Scientific

Rotary Evaporators | Fisher Scientific

Constructed of PTFE and glass to provide a chemically inert liquid Stuart™ Diagonal Coil Condenser Rotary Evaporator includes a long life graphite impregnated PTFE vacuum seal. £1766.30 – £1911.76 7 Cole-Parmer™ Stuart™ Rotary evaporator, cold finger condenser, plastic coated

Heidolph Instruments : Rotary Evaporators

Heidolph Instruments : Rotary Evaporators

Developed with users. In close cooperation with users, we developed the Hei-VAP series of rotary evaporators with an emphasis on the essentials: well thought-out details with a focus on features and functions to facilitate everyday laboratory work.

Alfa Laval - AlfaCond

Alfa Laval - AlfaCond

Alfa Laval AlfaCond condensers are specifically designed for condensing of vapour under vacuum. These plate surface condensers are ideal for use in applications such as vacuum condensers in evaporation systems, ethanol condensers in bioethanol plants, pan vapour condensers in sugar refineries, and as turbine condensers in small power plants.

Rotary evaporator - Wikipedia

Rotary evaporator - Wikipedia

Rotary evaporators are also used in molecular cooking for the preparation of distillates and extracts.. A simple rotary evaporator system was invented by Lyman C. Craig. It was first commercialized by the Swiss company Büchi in 1957. In research the most common form is the 1L bench-top unit, whereas large scale (e.g., 20L-50L) versions are used in pilot plants in commercial chemical operations.

Vacuum Condenser Flashing on Sub-Zero

Vacuum Condenser Flashing on Sub-Zero

Jan 30, 2014 · Sub-Zero Vacuum Condenser. Before I start this article I must disclose that there are many reasons your Sub-Zero may be blinking Vacuum Condenser. I am going to go over the most basic reason. Sub-Zero refrigerators in residential setting collect dust on their condensers. What is a refrigeration Condenser?

Vacuum Pump For Rotary Evaporator at Thomas Scientific

Vacuum Pump For Rotary Evaporator at Thomas Scientific

The rotary evaporator R-100 is a high-quality, entry level Rotavapor to meet the essential needs in classical laboratory applications. It is capable of a manually adjustable rotation speed of 20 to 280 rpm and equipped with an action jack lift for manual lifting of the evaporating flask. Included is.

MA 50L Rotary Evaporator with Dual Condenser & Flasks .

MA 50L Rotary Evaporator with Dual Condenser & Flasks .

MA 50L Rotary Evaporator with Dual Condenser & Flasks 15,000.00 – 16,800.00 Top Rated GL16 Cap for Chilling Fluid or Vacuum Connectors - Pack of 5 15.00

APV Evaporator Hndbook

APV Evaporator Hndbook

The plate evaporator is designed to operate at pressures extending from 10 psig (1.7 barg) to full vacuum when using any number of effects. However, the maximum pressure differential normally experienced between adjacent annuli during single effect operation is 15 psi (1 bar).

Rotary Evaporators | Fisher Scientific

Rotary Evaporators | Fisher Scientific

Rotary Evaporators; Rotary Evaporators 1 – 30 1132 . Interest Areas. Life Science; Chemicals; Chromatography; Industries; Fisherbrand; Outlet Corner; Events and Exhibitions. The Story of Science World; Activate Science; On-Site Exhibitions; Trade Shows; .

No Vacuum In A Multiple Effect Evaporator - Industrial .

No Vacuum In A Multiple Effect Evaporator - Industrial .

Jul 21, 2008 · No Vacuum In A Multiple Effect Evaporator - posted in Industrial Professionals: Dear Colleagues,I am now working on a 3-effect evaporator in my plant. The evaporator is mainly composed of 3 flash drums, 3 heat exchangers, and 1 final condenser. Steam and Vapor flow direction: steam from other production process goes to the 1st effect heat exchanger; the vapor from 1st flash drum goes to .

AC Condenser: How to Clean an Air Conditioning Condenser

AC Condenser: How to Clean an Air Conditioning Condenser

The evaporator usually sits in an inaccessible spot inside a metal duct downstream from the blower (Figure A). If you can get to it, gently vacuum its fins (from the blower side) with a soft brush as you did with the a/c condenser. However, the best way to keep it .

Antibodies & Protein Biology - Fisher Scientific

Antibodies & Protein Biology - Fisher Scientific

CentriVap™ concentrators, precise glove boxes, RapidVap™ vacuum evaporation system (1) CentriVap™ micro IR vacuum (2) CentriVap™ system (2) CentriVap™ vacuum concentrator (4) Centrifan™ PE (1) Cold trap (1) Condenser (fits glass assemblies V, C, S and CR) (1) Condenser set G3, G4, G6 of laborota 4000 rotary evaporator (1) Cooled .

Buchi Condenser at Thomas Scientific

Buchi Condenser at Thomas Scientific

.the condenser assembly of the rotary evaporator. This concept increases the flexibility of the Rotavapor whilst reducing the total evaporation time. Hence, excellent time and resource savings are achieved on a minimal footprint. Evaporate 6 x 150 ml in parallel One condenser, vacuum.

No Vacuum In A Multiple Effect Evaporator - Industrial .

No Vacuum In A Multiple Effect Evaporator - Industrial .

Jul 21, 2008 · No Vacuum In A Multiple Effect Evaporator - posted in Industrial Professionals: Dear Colleagues,I am now working on a 3-effect evaporator in my plant. The evaporator is mainly composed of 3 flash drums, 3 heat exchangers, and 1 final condenser. Steam and Vapor flow direction: steam from other production process goes to the 1st effect heat exchanger; the vapor from 1st flash drum goes to .

MA 50L Rotary Evaporator with Dual Condenser & Flasks .

MA 50L Rotary Evaporator with Dual Condenser & Flasks .

MA 50L Rotary Evaporator with Dual Condenser & Flasks 15,000.00 – 16,800.00 Top Rated GL16 Cap for Chilling Fluid or Vacuum Connectors - Pack of 5 15.00

Vacuum Condensers | Heat Exchanger Replacement | Wintek .

Vacuum Condensers | Heat Exchanger Replacement | Wintek .

Pre-condensers should always be considered when a significant amount of the process stream is condensable. A vacuum system that incorporates a pre-condenser will decrease the size of the pump required; thus, the total energy requirements and capital costs will be lower.

Condenser, Compressor & Lines for 2002 Lincoln Continental .

Condenser, Compressor & Lines for 2002 Lincoln Continental .

Condenser Mount Bracket, LEFT. UPPER--2 F8OZ19702AA F8OZ19702AA / Condenser Mount Bracket Condenser Mount Bracket, RIGHT. UPPER--3 F5OY19735B F5OY19735B / Condenser Mount Bracket Condenser Mount Bracket, LEFT. LOWER--3 F5OY19735A F5OY19735A / Condenser .

Rotary Film Evaporator - Thin Film Rotary Vacuum .

Rotary Film Evaporator - Thin Film Rotary Vacuum .

Send Inquiry Now! The Applications of Rotary Film Evaporator. The rotary evaporator is simply a chemical technique used in the efficient separation of liquids through the gentle separation of samples by evaporating solvents under a vacuum. This method is mostly preferred over other techniques as it is more efficient in getting pure solutions after the separation process.

Heidolph Instruments : Rotary Evaporators

Heidolph Instruments : Rotary Evaporators

Developed with users . In close cooperation with users, we developed the Hei-VAP series of rotary evaporators with an emphasis on the essentials: well thought-out details with a focus on features and functions to facilitate everyday laboratory work.

Rotary Evaporators | Trim Scene

Rotary Evaporators | Trim Scene

The new Ai dual 20L main condenser kit allows you to increase your SolventVap rotary evaporator condensation rate up to 75%. SE53-DC Standard Package Part description Quantity Main condenser for Ai SolventVap SE53 20L rotary evaporators. 1 pc Glass tee for main condensers 1 pc Glass 3/8" hose barb tee adapter 3 pcs Ai 80# QuickClamp set 2 sets

Standard Operating Procedure - Rotary Evaporator

Standard Operating Procedure - Rotary Evaporator

Some chemical procedures require a quick and effective separation of substances through evaporation. The Rotary Evaporator is a tool which puts the separable substance under vacuum and heats evenly through a spinning motion, causing one component to evaporate and leaving the first component behind. Engineering and Ventilation Controls

Schutte & Koerting - Barometric Condensers

Schutte & Koerting - Barometric Condensers

The steam vapors from the evaporator pass through a separator or catch-all, where any liquid carried in suspension is collected and drained back into the evaporator. The vapors pass on to the top inlet of the condenser where the condensing is accomplished by the spray nozzles.

Condenser System Vacuum Equipment in Sugar | Single Entry .

Condenser System Vacuum Equipment in Sugar | Single Entry .

Condenser system and vacuum equipment are common to evaporators and vacuum pans. Nearly all these vessels use direct contact condensers, where the cooling water comes into direct contact with the vapour to be condensed.. Creation of Vacuum:. a) In a condenser, we condense large volume of vapour and it will only produce a comparatively small volume of water or (condensate) and this water runs .